Supplies and Spare Parts

August 31, 2015

 

Engine, Engine Controls and Exhaust

2

Impellers with 2 o-rings each, new Cummins # 3897337 OK
1 Impeller key   OK

2

Belt, V ribbed, new Cummins # 3288689 OK
1 Fuel hand pump, new ? gasket used Cummins # OK
1 Gear oil pressure sensor, 0-25 bar new (VDO) Cummins # OK
1 Engine Relays Cummins # OK

 

5 Injectors and everything connected, used Cummins, use as last resort OK

 

4 Engine zinc electrodes plugs, new Cummins # 68241 OK

 

2 Engine fuel filter  (Cummins, on engine) FF5285 OK
0 Engine oil filter LF3959 OK


15l Engine oil and gear box oil Volvo Penta SAE 15 - 40 OK

 

10l Antifreeze Glycol OK

 

2 Exhaust hose, to replace muffler 125 mm ID OK


Fuel System

2 Separ fuel filter elements (square) Fleetguard FS19605 OK
1 Separ fuel bowl, glass, new   OK

10 Teflon fuel flanges seals    

 

2 m Vetus FUHOSE fuel hose ID 8mm, OD 16 mm  
2 m Vetus FUHOSE fuel hose ID 13mm, OD 22 mm  

 

Drive Shaft, Propeller and Zincs

4 PSS shaft seal nitrile o-rings ?  
2 Propeller nuts without zincs Bimetal, for 50 mm shafts  
2 Propeller nuts sacrificial zinc   OK
2 Propeller nut locks Stainless steel, for 50 mm shafts OK
0 Vetus sacrificial zincs Type 55, 4.5 kg each  

 

Steering

10 l Hydraulic oil Engler viscosity 1.8 - 2.5 at a temperature of 40 degrees C. BP Energol HP 10 or similar  

 

4 Delrin washers for under tiller arm    
1 316 SS 32mm x 120mm bolt for tiller arm  
2 316 SS washer for tiller arm bolt Stainless steel, for 50 mm shafts  
8 Rubber o-rings for the SS stocks Type 55, 4.5 kg each  
8 Rubber o-rings for the delrin bearings    

 

2 Sets of brushes for the electro hydraulic pump    

 

Generator

As of April 30, 2015

1 Engine fuel filter S112 or
Donaldson P550012
  OK
1 Engine air filter S181   OK
2 Engine oil filter, OD 68 mm, height 68 mm
1 last resort, smaller
Yamaha 5DM-13440-00
Yamaha 3GH-13440-20
Yanmar 119305-35151
OK

 

1 V-belt   OK
1 Johnson pump Impeller kits.  O ring is not used.  Only the paper seal.    OK
4 Johnson pump gaskets, with metal backing.  2 new, 2 used.   OK
1 Pierburg fuel pump, complete Type 51 OK
2 Rubberhose curves for cooling water Kubota 16241-72870 OK

Located in starboard hull,   where the generator is, in plastic box.  

 

AC Electric System

? 12 V AC dual pole relais Hager 521  
1 Bticino C16 circuit breaker GC8813AC16  

 

DC Electric System

   12V dual pole relay Hager 521  

1

Circuit breaker, 2 pole  200 A Blue Sea Systems 7269 www.nas.com/electric

  

Watermaker

1 Charcoal filter + FTC CC OK
0 5 micron filter (white) FTC 5 OK
0 20 micron filter (blue) FTC 20 OK
0 50 micron filter (red) FTC 20 OK
1 Filter case   0k
1 SCI storage compound boxes (10 2011) KIT CHEM OK
1 12 V DC high pressure pump motor, rebuilt   OK

 

Lights

1 Search light light bulb Philips H9, 12 V 65 W 12361  
2 Neon tubes 18 W  
1 Emergency lights,  LED courtesy lamps Hella marine 12V 0.7 W  

 

Batteries

2 Search light remote battery Sony alkaline 12V LR23A  
  Handheld GPS batteries Alkaline 1.5V type AA  

 

Heating and Cooling

10 l 25% glycol, 75 % water mixture   OK

 

Electronics

1 Raymarine rudder sensor    

 

Fuses

2 Generator control panel fuse ?? A (5 x 20 mm)  
1 Generator battery high amperage fuse 150 A  

 

1 VHF radio fuse 6 A 250 V (5 x 20 mm)  
1 TV Antenna amplifier fuse 250 mA (5 x 20 mm)  

 

2 Furuno MFD 12 fuse 10 A 125 V (6 x 30 mm)  
2 Furuno MFD 12 fuse 20 A 125 V (6 x 30 mm)  

 

4 DC Electric system high amperage fuse 250 A (Blue Sea 5107)  
1 Electric System AGC marine fuse 2 A (Ancor 601005)  

 

2 Anchor Windlass fuse ??A  (5 x 20 mm)  

 

2 Air handler control box fuse ??A   

 

2 Autopilot Core Pack fuse 3 A (Automotive type)  
1 Autopilot Core Pack fuse 15 A (Automotive type)  

One set of spare fuses is located inside the corepack box.

 

Electrical Material

1 Roll solder, resin core
5 Rolls electric tape
1 Tie wraps, various sizes
 
2015-08-31
cat_21 spares.htm